Wacker Neuson G 3.3A Betreibershandbuch

www.wackergroup.comGeneratorG 3.3AEOPERATOR’S MANUAL0154607en 0040403wam0154607EN

Safety Information G 3.3Awc_si000053gb.fm 82.5 Label Locationswc_gr000675 GND88897D A N G E RG E F A H RD A N G E RP E L I G R O S T O P

G 3.3A Safety Informationwc_si000053gb.fm 92.6 Safety and Operating LabelsWacker machines use international pictorial labels where needed.These labels

Safety Information G 3.3Awc_si000053gb.fm 10Open main circuit breaker.Open fuel flow valve.Close choke.Push or turn engine switch to ON position.Pull

G 3.3A Safety Informationwc_si000053gb.fm 11Close main circuit breaker.Push or turn engine switch to OFF position.Press engine crank switch to "O

Safety Information G 3.3Awc_si000053gb.fm 12A nameplate listing the Model Number, Item Number, Revision, and Serial Number is attached to each unit. P

G 3.3A Technical Datawc_td000056gb.fm 133. Technical Data3.1 GeneratorItem No. G3.3AE0008259GeneratorOutput kVA3.3Type Single voltage, single phase,

Technical Data G 3.3Awc_td000056gb.fm 143.2 Engine3.3 Sound SpecificationsThe required sound specification, Paragraph 1.7.4.f of 89/392/EECMachinery D

G 3.3A Operationwc_tx000150gb.fm 154. Operation4.1 Application and Power RequirementsThis generator is designed to operate single-phase, 50 Hz applian

Operation G 3.3Awc_tx000150gb.fm 164.2 Indoor InstallationIf the generator must be installed indoors, adequate ventilation orexhaust hoses must be pro

G 3.3A Operationwc_tx000150gb.fm 174.4 Grounding the GeneratorSee Graphic: wc_gr000544The generator should be grounded to a good ground source incompl

DANGERCARBON MONOXIDEUsing a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains carbon

Operation G 3.3Awc_tx000150gb.fm 184.5 Generator DeratingAll generators are subject to derating for altitude and temperature.Internal combustion engin

G 3.3A Operationwc_tx000150gb.fm 194.6 Use of Extension CordsWhen a long extension cord is used to connect an appliance or tool tothe generator, a vol

Operation G 3.3Awc_tx000150gb.fm 204.7 Earth-leakage Circuit BreakerSee Graphic: wc_gr000661Generator models ending with an “AE” are equipped with an

G 3.3A Operationwc_tx000150gb.fm 214.8 Control PanelSee Graphic: wc_gr000679The generator is protected by a 15 amp circuit breaker (a) located onthe c

Operation G 3.3Awc_tx000150gb.fm 224.9 Before Starting4.9.1 Read and understand safety and operating instructions at beginning ofthis manual. 4.9.2 Re

G 3.3A Operationwc_tx000150gb.fm 234.10 To RunSee Graphic: wc_gr000679 and wc_gr0006654.10.1 Disconnect all loads from the generator and place main ci

Maintenance G 3.3Awc_tx000161gb.fm 245. Maintenance5.1 Engine MaintenanceThe chart below lists basic machine and engine maintenance. Refer toengine ma

G 3.3A Maintenancewc_tx000161gb.fm 255.3 Engine OilSee Graphic: wc_gr0000225.3.1 Drain oil while the engine is still warm.5.3.2 Remove the oil fill pl

Maintenance G 3.3Awc_tx000161gb.fm 265.4 Air CleanerSee Graphic: wc_gr000025The engine is equipped with a dual element air cleaner. Service aircleaner

G 3.3A Maintenancewc_tx000161gb.fm 275.5 Spark PlugSee Graphic: wc_gr000028Clean or replace spark plug as needed to ensure proper operation.Refer to t

G 3.3AE Table of Contentswc_bo0154607enTOC.fm 11. Foreword 32. Safety Information 42.1 Laws Pertaining to Spark Arresters ...

Maintenance G 3.3Awc_tx000161gb.fm 285.6 Cleaning the Sediment CupSee Graphic: wc_gr0000295.6.1 Turn fuel valve off. 5.6.2 Remove sediment cup (a) and

G 3.3A Maintenancewc_tx000161gb.fm 295.8 Engine SpeedSee Graphic: wc_gr000114Adjust engine to the no load or idle speed per the Technical Data.5.8.1 S

Maintenance G 3.3Awc_tx000161gb.fm 305.9 StorageBefore storing generator for a long period of time:5.9.1 Close the fuel valve and remove and empty sed

G 3.3A Maintenancewc_tx000161gb.fm 315.11 Troubleshooting Problem / Symptom Reason / RemedyIf engine doesn't start, check that:• Engine switch is

Maintenance G 3.3Awc_tx000161gb.fm 325.12 Wiring SchematicSee Graphic: wc_gr000680 Ref. Description Ref. Description Ref. DescriptionA Generator

2003-CE-Generators33Q.fmWilliam Lahner Dan DomanskiVice President of Engineering Manager, Product EngineeringWACKER CORPORATIONDate / Datum / Fecha /

Wacker Construction Equipment AG · Preußenstraße 41 · D-80809 München · Tel.: +49-(0)89-354 02 - 0 · Fax: +4

Table of Contents G 3.3AEwc_bo0154607enTOC.fm 25. Maintenance 245.1 Engine Maintenance ...

Forewordwc_si000053gb.fm 31. ForewordThis manual provides information and procedures to safely operateand maintain this Wacker model. For your own saf

Safety Information G 3.3Awc_si000053gb.fm 42. Safety InformationThis manual contains DANGER, WARNING, CAUTION, and NOTEcallouts which must be followed

G 3.3A Safety Informationwc_si000053gb.fm 52.2 Operating SafetyBACKFEED FROM THE GENERATOR INTO THE PUBLIC POWERDISTRIBUTION SYSTEM CAN CAUSE SERIOUS

Safety Information G 3.3Awc_si000053gb.fm 62.2.11 ALWAYS transport generator in an upright position.2.2.12 ALWAYS keep machine at least one meter (thr

G 3.3A Safety Informationwc_si000053gb.fm 72.4 Service SafetyPoorly maintained equipment can become a safety hazard! In orderfor the equipment to ope